Evaporator Fan Motor Repair

Turn the panel over so the fan blades are exposed and pull the fan blades off of the motor shaft.

Evaporator fan motor repair.

Turn the evaporator cover back over and lift the two locking tabs on the top of the plastic fan housing with needle nose pliers rotate motor retainer counter clockwise and remove. See related items for self tapping screw. If the evaporator fan motor isn t working the air in the refrigerator and freezer warms up. Remove the old motor lift the locking tabs with pliers.

Then slide the motor assembly into place on the plastic mounting bracket. Insert the old grommet on the back central shaft on the motor. A compressor for example can cost about 200 and an ice maker costs about 300 on average. Evaporator cooling coil fan motor assembly with wire harness 115 volts.

I called a repair service they said they would come in 3 days then 7 20 days for ordering necessary parts. The evaporator fan motor is located behind the rear panel of the freezer but before you can access that panel you ll need to unscrew the hardware holding any air ducts in place on the back of the freezer and then slide them out. Refrigerator evaporator fan motor. Slide the top cover over the shaft on top of the motor then secure it in place by tightening the two screws.

My repair advice. Replace the evaporator fan motor with the manufacturer approved replacement part for your model. I also knew there was a fan to move the air. Rotate the motor retainer on top counter clockwise to unlock and remove.

When the evaporator fan motor fails it often generates a lot of noise in the freezer area. Install the new evaporator fan motor. Replacement parts and labor compressors ice makers defrosters fan motors evaporator fan motors freezer components a door seal and circuit boards are some of the more frequent appliance parts that need repair. The evaporator fan motor draws air over the evaporator cooling coils and circulates the cold air through the refrigerator and freezer compartments.

This video is intended to give you the general idea of the part replacement procedure. Per manufacturer screw holes in motor are not threaded from the factory use old screws. Remove old motor block and toss. Set the fan blades aside.

When the evaporator fan motor fails it often generates a lot of noise in the freezer area. The evaporator fan blows air through the evaporator before circulating cooled air to the freezer and refrigerator compartment. Appliance parts pros helped in determining it must be the the evaporator fan.